Odisha CHSE VOC-ITV Four Wheeler Service Technician case studies
Odisha CHSE VOC-ITV Four Wheeler Service Technician · Put your knowledge to work in context.
The Odisha CHSE Vocational (ITV) Four Wheeler Service Technician credential is a higher secondary vocational trade qualification for students who intend to inspect, service, diagnose and repair cars and light commercial vehicles. It is aimed at candidates who want a practical, workshop-based route into the motor trade rather than a purely academic science stream, and it also supports progression into apprenticeships, dealership service departments, independent garages and further technical study. The Odisha CHSE VOC-ITV Four Wheeler Service Technician case studies are 5 cases and about 3,510 words.
1Loaded Pickup on a Two-Post Hoist
A 1.7-tonne light commercial pickup is booked for a clutch replacement. The workshop has a 3.5-tonne two-post hoist.
782 words, about 4 min2Overheated Diesel Head and a Cheap-Gasket Request
A 2.5-litre four-cylinder diesel engine from a 2016 pickup has covered 180,000 km. The owner ignored a split coolant hose; the temperature gauge reached the red zone and the engine stalled.
735 words, about 4 min3Common-Rail Diesel Low Rail Pressure
A 2.2-litre common-rail diesel SUV comes in with P0087 and limp mode. At idle the rail pressure is 250 bar; at 3,000 rpm under load the desired pressure is 1,400 bar but actual is 780 bar.
674 words, about 3 min4Pickup Vibration and Clutch Judder After a Clutch Job
A rear-wheel-drive pickup has a vibration between 80 and 100 km/h that is worse under acceleration and almost disappears when the clutch is pressed and the vehicle coasts in neutral. The owner also reports a judder when pulling away, especially when the vehicle is hot.
624 words, about 3 min5Overnight Battery Drain With an Aftermarket Dash Camera
A 1.5-litre petrol sedan will not start after standing for three days. The battery is a two-year-old 60 Ah unit, rests at 12.2 V, and the charging system holds 14.2 V.
695 words, about 3 min