Maharashtra SSC Automotive Service Technician Pre-Voc/NSQF case studies
Maharashtra SSC Automotive Service Technician Pre-Voc/NSQF · Put your knowledge to work in context.
The Maharashtra SSC Automotive Service Technician course is a vocational/NSQF subject offered within the State Board's Secondary School Certificate stream, delivered through schools and vocational institutions approved by MSBSHSE. It suits students who want a Class 10 credential with a practical trade skill attached, and it also serves as an entry point into the automobile service industry or into further technical study such as ITI Motor Mechanic or diploma programmes. The Maharashtra SSC Automotive Service Technician Pre-Voc/NSQF case studies are 5 cases and about 3,857 words.
1Petrol Vapour, a Chipped Disc and an Unlocked Lift
On a wet July afternoon a petrol hatchback with a strong fuel smell is pushed into bay 3 of a small car workshop for a fuel-pump replacement. The car sits on a two-post lift, but both nearside arms are under the painted side sill instead of the reinforced jacking points, and the front-left arm's locking pawl has not clicked in.
844 words, about 4 min2Bore Readings Taken With a Dropped Micrometer
A 1.2-litre four-cylinder petrol engine is stripped for overhaul after overheating. The workshop's 50–75 mm outside micrometer was dropped last month; checked against a certified 50.00 mm gauge block it now reads 50.03 mm, and the error is treated as constant across its range.
763 words, about 4 min3Clutch Comeback 900 km After Overhaul
A 2018 1.5-litre diesel sedan with a six-speed manual gearbox and a dual-mass flywheel comes back 900 km after a clutch overhaul billed at 18,500 rupees. The clutch plate, cover assembly and release bearing were replaced; the flywheel was sent to a nearby lathe shop for a light reface that removed 0.6 mm, and no dial-gauge reading was taken before or after.
748 words, about 4 min40.09 A Drain on a 35 Ah Battery
A 2020 petrol hatchback with a 35 Ah battery comes in after going flat twice in one week. The battery passes a load test, holds 12.4 V after two hours at rest, and the alternator gives 14.1 V at 2,000 rpm with lights, blower and rear demister on.
782 words, about 4 min5DPF Full on a School-Run Diesel
A 2021 BS-VI diesel SUV with 38,000 km on the clock is used almost entirely for school runs of under 5 km. The DPF warning lamp and an exhaust-filter-full message appeared two weeks ago, and the owner ignored them until the engine dropped into limp mode.
720 words, about 4 min